Product ID:R7K50 ACCELERATOR REDUCER ULTRA-FILL II
MSDS Date:07/16/1992
FSC:8010
NIIN:00F040642
MSDS Number: BXMCF

SHERWIN-WILLIAMS CO

101 PROSPECT AVE N W
CLEVELAND, OH 44115-1042
US

Emergency Phone: 216-566-2917/216-566-2902

Info Phone: 216-566-2902/216-566-2917

Cage: 54636

SHERWIN-WILLIAMS CO THE

CLEVELAND, OH 44115-1042 US

Telephone: 800-251-2486/216-566-2242

Cage: 54636

LIGHT ALIPHATIC NAPHTHA, VM & P NAPHTHA, LACOLENE

CAS: 64742-89-8

Fraction By Weight: 8%

OSHA PEL 100 PPM

ACGIH TLV: 100 PPM

TOLUENE (IARC CARC- GROUP 3) *95-2*

CAS: 108-88-3

RTECS: XS5250000

Fraction By Weight: 3%

OSHA PEL 100 PPM

ACGIH TLV: 100 PPM

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

HEXONE, METHYL ISOBUTYL KETONE (MIBK), 4-METHYL-2-PENTANONE

CAS: 108-10-1

RTECS: SA9275000

Fraction By Weight: 15%

OSHA PEL 410 MG/CUM

ACGIH TLV: 205 MG/CUM

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

N-BUTYL PROPIONATE

CAS: 590-01-2

RTECS: UE8245000

Fraction By Weight: 26%

BUTYL ACETATE (N-BUTYL ACETATE) *95-2*

CAS: 123-86-4

RTECS: AF7350000

Fraction By Weight: 46%

OSHA PEL 710 MG/CUM

ACGIH TLV: 713 MG/CUM

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

7.03 LBS/GAL.

RTECS: 9999999VO

Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:IRRITATION OF THE EYES, SKIN &
RESPIRATORY SYSTEM. MAY CAUSE NERVOUS SYSTEM DEPRESSION.
OVEREXPOSURE MAY RESULT IN DEATH. OVEREXPOSURE TO SOLVENTS MAY
CAUSE ADVERSE EFFECTS TO THE LIVER, URINARY, BLOO D FORMING,
CARDIOVASCULAR & REPRODUCTIVE SYSTEMS & MAY CAUSE PERMANENT BRAIN &
NERVOUS SYSTEM DAMAGE. (SEE SUPP)
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, UNCONSCIOUSNESS, HEADACHE,
DIZZINESS, NAUSEA, LOSS OF COORDINATION, REDNESS, ITCHING, BURNING
SENSATION
Medical Cond Aggravated by Exposure:NONE

First Aid:INHALATION: LEAVE AREA & GET FRESH AIR. SKIN: WASH
THOROUGHLY W/SOAP & WATER. EYES: FLUSH W/LARGE AMOUNTS OF WATER FOR
15 MINS. OBTAIN MEDICAL ATTENTION IN ALL CASES.

Flash Point:67F
Lower Limits:0.7
Upper Limits:98.8
Extinguishing Media:CO2, DRY CHEMICAL, FOAM
Fire Fighting Procedures:FULL PROTECTIVE EQUIPMENT & SCBA. WATER SPRAY
MAY BE INEFFECTIVE. IF WATER IS USED, FOG NOZZLES ARE PREFERRED.
WATER MAY BE USED TO COOL CLOSED CONTAINERS.
Unusual Fire/Explosion Hazard:CLOSED CONTAINERS MAY EXPLODE WHEN
EXPOSED TO EXTREME HEAT. APPLICATION TO HOT SURFACES REQUIRES
SPECIAL PRECAUTIONS.

Spill Release Procedures:REMOVE ALL IGNITION SOURCES. VENTILATE &
REMOVE W/INERT ABSORBENT.

Handling and Storage Precautions:KEEP CONTAINER CLOSED WHEN NOT IN USE
& AWAY FROM IGNITION SOURCES. TRANSFER ONLY TO APPROVED LABELED
CONTAINERS. USE ONLY W/ADEQUATE VENTILATION.
Other Precautions:USE APPROVED BONDING/GROUNDING PROCEDURES. KEEP OUT
OF REACH OF CHILDREN. DON'T TAKE INTERNALLY. AVOID CONTACT
W/SKIN/EYES & BREATHING OF VAPOR/MIST. INTENTIONAL MISUSE BY
DELIBERATELY CONCENTRATING/I NHALING CONTENTS CAN BE HARMFUL/FATAL.

Respiratory Protection:OVERSPRAY: A NIOSH/MSHA APPROVED POSITIVE
PRESSURE AIR SUPPLIED RESPIRATOR SHOULD BE WORN. IF UNAVAILABLE: A
NIOSH/MSHA APPROVED PROPERLY FITTED ORGANIC VAPOR/PARTICULATE
RESPIRATOR.
Ventilation:LOCAL EXHAUST PREFERABLE. GENERAL EXHAUST ACCEPTABLE IF
EXPOSURE IS MAINTAINED BELOW APPLICABLE EXPOSURE LIMITS.
Protective Gloves:REQUIRED
Eye Protection:SAFETY GLASSES W/UNPERFORATED SIDESHIELD
Other Protective Equipment:BARRIER CREAMS. WHEN SANDING/ABRADING DRIED
FILM, USE A NIOSH/MSHA APPROVED PARTICULATE RESPIRATOR.
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE. WASH THOROUGHLY AFTER USE.
Supplemental Safety and Health
HEALTH HAZARDS CONT'D: ACETATES CAN BE ABSORBED THROUGH THE SKIN.
DURING USE & UNTIL VAPORS ARE GONE: KEEP AREA VENTILATED, DON'T
SMOKE, EXTINGUISH IGNITION SOURCES & WEAR A RESPIRATOR. NO PERSON
SHOU LD BE ALLOWED IN THE AREA WHERE PRODUCTIS USED UNLESS EQUIPPED
W/RESPIRATOR.

Boiling Pt:B.P. Text:200-360F
Vapor Density:>1
Spec Gravity:0.85-1.3
Evaporation Rate & Reference:SLOWER THAN ETHER
Percent Volatiles by Volume:25-100

Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:HEAT, SPARKS, OPEN FLAME, ELECTRICAL
EQUIPMENT & OTHER IGNITION SOURCES
Hazardous Decomposition Products:CO2, CO, OXIDES OF METALS.

Waste Disposal Methods:WASTE MUST BE TESTED FOR IGNITABILITY TO
DETERMINE THE APPLICABLE EPA HAZARDOUS WASTE NUMBER. INCINERATE IN
APPROVED FACILITY. DON'T INCINERATE CLOSED CONTAINERS. DISPOSE OF
IN ACCORDANCE W/LOCAL, STA TE & FEDERAL REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.